`MANUAL
`
`Pinnacle(cid:153) 20 kW
`(400(cid:150)1000 Vdc)
`DeviceNet(cid:153) with MDXL User,
`Terminal Block Output
`5702199-A
`April 2001
`
`Advanced Energy Industries, Inc.
`1625 Sharp Point Drive
`Fort Collins, CO 80525 USA
`970.221.4670
`
`technical.support@aei.com
`
`Page 1 of 182
`
`INTEL EXHIBIT 1062
`
`
`
`Advanced Energy®
`
`ii
`
`5702199-A
`
`Page 2 of 182
`
`
`
`User Manual
`
`Pinnacle™ 20 kW
`
`5702199-A
`
`Page 3 of 182
`
`
`
`Advanced Energy®
`
`Copyright
`
`This manual and the information contained herein is the property of Advanced Energy Industries, Inc.
`No part of this manual may be reproduced or copied without the express written permission of
`Advanced Energy Industries, Inc. Any unauthorized use of this manual or its contents is strictly
`prohibited. Copyright © 4/13/01 by Advanced Energy Industries, Inc. All Rights Reserved.
`
`Disclaimer and Limitation of Liability
`
`The information contained in this manual is subject to change by Advanced Energy Industries,
`Inc. without prior notice. Advanced Energy Industries, Inc. makes not warranty of any kind
`whatsoever, either expressed or implied, with respect to the information contained herein.
`Advanced Energy Industries, Inc. shall not be liable in damages, of whatever kind, as a result
`of the reliance on or use of the information contained herein.
`
`Product Usage Statement
`
`Read this entire manual and all other publications pertaining to the work to be
`performed before you install, operate, or maintain this equipment. Practice all plant and
`product safety instructions and precautions. Failure to follow instructions can cause
`personal injury and/or property damage. All personnel who work with or who are
`exposed to this equipment must take precautions to protect themselves against serious
`or possibly fatal bodily injury.
`
`Advanced Energy Industries, Inc., (AE) provides information on its products and
`associated hazards, but it assumes no responsibility for the after-sale operation of the
`equipment or the safety practices of the owner or user. This equipment produces or uses
`potentially lethal high-voltage, high-current, radio frequency (RF) energy. NEVER
`DEFEAT INTERLOCKS OR GROUNDS.
`
`Trademark Information
` is a registered trademark of Advanced Energy Industries, Inc.
`
`Advanced Energy is a registered trademark of Advanced Energy Industries, Inc.
`AE is a registered trademark of Advanced Energy Industries, Inc.
`DeviceNet is a trademark of Open DeviceNet Vendor Association, Inc., Boca Raton, FL.
`Pinnacle is a trademark of Advanced Energy Industries, Inc.
`
`iv
`
`5702199-A
`
`Page 4 of 182
`
`
`
`Pinnacle™ 20 kW
`
`Table of Contents
`
`Chapter 1. Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1
`
`Read This Section! . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1
`Interpreting the Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1
`Type Conventions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1
`Icons (Symbols) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1
`Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3
`Product Safety/Compliance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-4
`Directives . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-4
`Standards. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-4
`Installation Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-5
`Conditions of Use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-5
`
`Chapter 2. Theory . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1
`
`General Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1
`Output Impedance Range . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1
`Output Regulation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1
`Interfaces. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1
`Microprocessor Advantages . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2
`Displays . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2
`Arc-Suppression Feature. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2
`Theory of Operation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2
`Input. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3
`Housekeeping Supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3
`Inverter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3
`Output . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3
`Output Measurement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-4
`Logic Control. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-4
`Remote Interfaces . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-4
`
`Chapter 3. Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1
`
`Functional Specifications. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1
`Physical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3
`Electrical Specifications. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-4
`Environmental Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-8
`Coolant Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-9
`
`5702199-A
`
`Table of Contents
`
`v
`
`Page 5 of 182
`
`
`
`Advanced Energy®
`
`Chapter 4. I/O Communication and Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1
`
`User Port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1
`Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1
`Signals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1
`Pin-description Table . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-2
` DeviceNet™ Port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-4
`Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-5
`Pin Descriptions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-5
`Rotary Switches: Baud Rate and Addressing . . . . . . . . . . . . . . . . . . . . . . 4-5
`Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-6
`Poll Command Message . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-7
`Response Message . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-8
`Explicit Messaging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-9
`Rear Panel LEDs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-9
`Module Status LED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-10
`Network Status LED. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-11
`Passive Display Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-12
`Display . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-12
`LEDs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-13
`Active Front Panel/ Pinnacle Remote Panel . . . . . . . . . . . . . . . . . . . . . . . . . 4-13
`Connecting to the Remote Active Panel . . . . . . . . . . . . . . . . . . . . . . . . . . 4-14
`Understanding the Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-15
`Control Key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-15
`Output Display Screen . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-15
`Soft Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-15
`Modify Knob . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-16
`Regulation Switch. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-16
`On/Off switches & LEDs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-16
`Arc LED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-16
`Control Panel Interface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-16
`Output Power Switches . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-17
`Control Switches . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-17
`Regulation Switches. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-18
`Two-Line Output Display Screen . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-18
`Soft Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-19
`Modify Knob . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-19
`Control Panel Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-19
`Understanding the Menu Options . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-20
`Using the Service Functions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-22
`Checking Service-type Faults . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-23
`Checking Service-type Statistics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-23
`Checking the Total Energy Output. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-23
`Checking the Amount of Idle Time . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-23
`Checking the Number of Faults . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-23
`Checking the Number of Cycles. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-24
`Debugging Your Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-24
`
`vi
`
`Table of Contents
`
`5702199-A
`
`Page 6 of 182
`
`
`
`Pinnacle™ 20 kW
`
`Checking Your Master/Slave System . . . . . . . . . . . . . . . . . . . . . . . . . . 4-24
`Checking Your Hardware Configuration . . . . . . . . . . . . . . . . . . . . . . . 4-25
`Checking Your Communications Card . . . . . . . . . . . . . . . . . . . . . . . . . 4-25
`Checking Your Software Logic. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-25
`Checking Your ROM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-25
`Checking Your Software Versions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-25
`Using the Supply Functions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-26
`Setting the AE Bus Timeout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-26
`Setting the Supply Parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-26
`Setting the Panel Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-27
`Selecting Remote or Local Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-27
`Selecting a Lock Code. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-27
`Selecting the Number of Clicks. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-27
`Setting the Program Source . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-28
`Using Process Functions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-28
`Monitoring Your Process . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-28
`Establishing a Minimum Process Voltage. . . . . . . . . . . . . . . . . . . . . . . 4-29
`Setting an Out-of-Setpoint Timer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-29
`Changing the Target Functions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-30
`Setting Process Limits . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-31
`Setting a Strike Voltage Limit. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-31
`Setting a Maximum Limit for Output Voltage . . . . . . . . . . . . . . . . . . . 4-32
`Setting the Maximum Limit for Output Current . . . . . . . . . . . . . . . . . . 4-32
`Setting the Maximum Limit for Output Power . . . . . . . . . . . . . . . . . . . 4-32
`Setting Arc Handling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-33
`Setting the Voltage Arc Trip Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-33
`Setting the Arc Count Limit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-33
`Viewing the Arc Density . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-34
`Setting the Length of the Arc Average Window . . . . . . . . . . . . . . . . . . 4-34
`Setting the ARC Times . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-35
` Predefined Arc Handling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-35
`Enabling Arc Handling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-36
`Setting Control Parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-36
`Setting Recipes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-37
`Setting Ripple Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-38
`Using the Target Conditioning Cycle (TCC) . . . . . . . . . . . . . . . . . . . . . . 4-38
`Enabling Target Conditioning Cycle (TCC) . . . . . . . . . . . . . . . . . . . . . 4-38
`Setting the Target Conditioning Cycle (TCC) TIMER . . . . . . . . . . . . . 4-39
`Setting Joule Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-39
`Setting the Joule Setpoint . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-39
`Setting the Joule Threshold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-40
`Setting the Ramp. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-40
`Standard Serial (Flash) Port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-41
`Standard Serial Port Description. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-41
`Transmission Parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-42
`AE Bus Serial Communications (Host) Port . . . . . . . . . . . . . . . . . . . . . . . . 4-42
`Pin Descriptions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-43
`
`5702199-A
`
`Table of Contents
`
`vii
`
`Page 7 of 182
`
`
`
`Advanced Energy®
`
`Transmission Parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-44
`Using DIPs to Set the Pinnacle Unit’s Network Address . . . . . . . . . . . . . 4-44
`Switch Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-44
`External DIPs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-45
`Internal DIPs. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-46
`Min-switches . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-47
`Setting the Pinnacle Unit’s Network Address . . . . . . . . . . . . . . . . . . . . 4-48
`Setting Baud Rates and Communication Mode . . . . . . . . . . . . . . . . . . . 4-49
`Host/Pinnacle Communications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-49
`Communications Protocol . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-50
`Header. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-50
`Command . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-51
`Optional Length Byte . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-51
`Data (Data Bytes) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-51
`Checksum . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-51
`Creating an Ideal Communications Transaction . . . . . . . . . . . . . . . . . . . . 4-52
`Understanding Command Status Response (CSR) Codes . . . . . . . . . . . . . 4-53
`Host/Pinnacle Software Commands . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-55
`Host Port Command Sequence Examples . . . . . . . . . . . . . . . . . . . . . . . . . 4-87
`Example 1: Setting the Timeout Value. . . . . . . . . . . . . . . . . . . . . . . . . . 4-87
`Example 2: Setting Target Life . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-88
`Unit Illustrations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-90
`
`Chapter 5. Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1
`
`Unpacking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1
`Meeting Spacing Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1
`Cooling Requirements. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-3
`Cabinet Design. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-3
`Making Rear Panel Connections. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-6
`Grounding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-6
`Connecting a Pinnacle Remote Active Panel. . . . . . . . . . . . . . . . . . . . . . . . 5-6
`Connecting a Remote Passive Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-7
`Connecting for User Port Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-7
`Connecting to the Standard Serial Port . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-7
`Connecting for Serial (Host) Port Control . . . . . . . . . . . . . . . . . . . . . . . . . . 5-7
`Contactor Interlock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-7
`Connecting for DeviceNet™ Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-8
`Connecting Input Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-8
`Connecting Output Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-10
`Terminal Block Output Connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-10
`Connecting for Master/Slave . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-12
`Configuring Your Master Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-13
`Configuring Your Slave Units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-13
`Monitoring Your Master / Slave System . . . . . . . . . . . . . . . . . . . . . . . . 5-15
`Clearing Faults in a Master/Slave System . . . . . . . . . . . . . . . . . . . . . . . 5-15
`Understanding Master/Slave Input On/Off Combinations . . . . . . . . . . . 5-16
`
`viii
`
`Table of Contents
`
`5702199-A
`
`Page 8 of 182
`
`
`
`Pinnacle™ 20 kW
`
`Back Panel Illustration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-19
`
`Chapter 6. Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-1
`
`Operating Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-1
`Understanding Pinnacle™ Arc Handling . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-2
`Voltage Arc Trip Level. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-3
`TCC Algorithm Enable. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-3
`Target Type: Metal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-4
`Target Type: Non-Metal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-4
`Target Type: Custom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-4
`Arc Detect Delay Time . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-4
`Arc Shutdown Time . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-5
`Arc Recovery Test . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-5
`Arc Recovery Time. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-5
`
`Chapter 7. Troubleshooting and Customer Support . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-1
`
`Before Calling AE Global Support . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-1
`First Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-1
`Checks with the Power Off. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-1
`Checks with the Power On . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-2
`Checks if the Output Does Not Turn On . . . . . . . . . . . . . . . . . . . . . . . . . . 7-3
`Help Code Troubleshooting Table . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-3
`Passive Display Panel Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-5
`LED Troubleshooting Table . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-6
`Clearing the Error Code . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-7
`Error Code Troubleshooting Table . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-8
`Error E081 Fault Vector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-16
`Slave Status Low Byte. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-16
`Slave Status High Byte . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-17
`Personality Card Status . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-17
`AE Global Support. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-18
`Returning Units for Repair. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-19
`Warranty. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-19
`Authorized Returns . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-20
`Warranty Statement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-20
`
`5702199-A
`
`Table of Contents
`
`ix
`
`Page 9 of 182
`
`
`
`Advanced Energy®
`
`x
`
`Table of Contents
`
`5702199-A
`
`Page 10 of 182
`
`
`
`Pinnacle™ 20 kW
`
`List of Figures
`
`Figure 2-1. Pinnacle functional block diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2-3
`Figure 3-1. Operating range . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-7
`Figure 3-2. Impedance range . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-8
`Figure 4-1. 15-pin User port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-1
`Figure 4-2. DeviceNet™ port with pin designations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-5
`Figure 4-3. DeviceNet rotary switches and LEDs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-6
`Figure 4-4. Remote active panel connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-14
`Figure 4-5. Control panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-17
`Figure 4-6. Control panel main menu functions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-20
`Figure 4-7. Service menu map . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-21
`Figure 4-8. Supply menu map . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-21
`Figure 4-9. Process menu map . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-22
`Figure 4-10. Standard Serial port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-41
`Figure 4-11. Host port connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-43
`Figure 4-12. Rocker DIP switch (internally located on a master/slave interface card) . . . .4-45
`Figure 4-13. Slide DIP switch (externally located on units without a master/slave card) . .4-45
`Figure 4-14. Orientation of the Host port and DIP switch on the back panel (units without a
`master/slave interface card installed) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-46
`Figure 4-15. Location of the internal DIP switch on the master/slave interface card . . . . .4-47
`Figure 4-16. Graphic representation of a message packet . . . . . . . . . . . . . . . . . . . . . . . . . .4-50
`Figure 4-17. AE Bus communications transaction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-52
`Figure 4-18. Communications transaction example . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-55
`Figure 4-19. Passive front panel (front view) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-90
`Figure 4-20. Active front panel (front view) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-91
`Figure 4-21. Remote panel (front view) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-92
`Figure 4-22. Remote panel (rear view) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-93
`Figure 4-23. Remote panel (dimensions) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-94
`Figure 5-1. Dimensional drawing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-2
`Figure 5-2. Top, side, and inter-unit clearance for Pinnacle units stacked in a cabinet . . . . .5-5
`Figure 5-3. Contactor interlock connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-8
`Figure 5-4. Rear view of terminal block housing without strain relief attached. . . . . . . . .5-11
`Figure 5-5. Pinnacle master/slave interface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-13
`Figure 5-6. Configuration for Pinnacle master/slave system . . . . . . . . . . . . . . . . . . . . . . . .5-14
`Figure 5-7. Passive and active front panel (rear view) . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-19
`
`5702199-A
`
`List of Figures
`
`xi
`
`Page 11 of 182
`
`
`
`Advanced Energy®
`
`xii
`
`List of Figures
`
`5702199-A
`
`Page 12 of 182
`
`
`
`Pinnacle™ 20 kW
`
`List of Tables
`
`Table 1-1. Electromagnetic Compatibility (EMC) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-4
`Table 1-2. Safety Directives . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1-4
`Table 3-1. Functional Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-1
`Table 3-2. Physical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-3
`Table 3-3. Electrical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-4
`Table 3-4. Climatic Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-8
`Table 3-5. Coolant Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3-9
`Table 4-1. User Port Pin Descriptions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-2
`Table 4-2. DeviceNet™ Pin Descriptions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-5
`Table 4-3. Structure of the poll command message . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-7
`Table 4-4. Structure of the poll command message . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-8
`Table 4-5. MOD Status LED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-10
`Table 4-6. Network Status LED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-11
`Table 4-7. Passive Display Panel Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-12
`Table 4-8. Display Panel LEDs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-13
`Table 4-9. Remote Panel Pin Descriptions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-14
`Table 4-10. Strike Voltage Limit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-32
`Table 4-11. Arc detect, arc shutdown, and TCC times for pre-defined targets . . . . . . . . . .4-35
`Table 4-12. Serial Port Pin Descriptions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-42
`Table 4-13. AE Bus (Host) Port Pin Descriptions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-43
`Table 4-14. Address Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-48
`Table 4-15. Setting Switch 8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-49
`Table 4-16. Baud Rate Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-49
`Table 4-17. Command Status Response (CSR) Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-53
`Table 4-18. Host Port Commands . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-55
`Table 5-1. Minimum CFM Required for a Pinnacle Supply . . . . . . . . . . . . . . . . . . . . . . . . .5-3
`Table 5-2. Approximate Cooling Requirements for Three Supplies Mounted in a Cabinet .5-4
`Table 5-3. Input Sequences for Master and Slave Units . . . . . . . . . . . . . . . . . . . . . . . . . . .5-16
`Table 7-1. Help Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7-3
`Table 7-2. Passive Display Panel Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7-5
`Table 7-3. Troubleshooting LEDs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7-6
`Table 7-4. Error Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7-8
`Table 7-5. AE Global Support Locations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7-18
`
`5702199-A
`
`List of Tables
`
`xiii
`
`Page 13 of 182
`
`
`
`Advanced Energ