`Master/Slave AE Bus,
`DeviceNet™, MDXL User,
`UHF Output
`
`March 2005 5702269-C
`
`User Manual
`
`Page 1 of 204
`
`INTEL EXHIBIT 1024
`
`
`
`Page 2 of 204
`
`Page 2 of 204
`
`
`
`User Manual
`
`Pinnacle(cid:153) Plus+ 10 kW
`
`5702269-C
`
`Page 3 of 204
`
`
`
`Advanced Energy®
`
`COPYRIGHT
`This manual and the information contained herein is the proprietary property of
`Advanced Energy Industries, Inc.
`
`No part of this manual may be reproduced or copied without the express written
`permission of Advanced Energy Industries, Inc. Any unauthorized use of this manual
`or its contents is strictly prohibited. Copyright © 2004 Advanced Energy Industries,
`Inc. All Rights Reserved.
`
`DISCLAIMER AND LIMITATION OF LIABILITY
`
`The information contained in this manual is subject to change by Advanced Energy
`Industries, Inc. without prior notice. Advanced Energy Industries, Inc. makes no
`warranty of any kind whatsoever, either expressed or implied, with respect to the
`information contained herein. Advanced Energy Industries, Inc. shall not be liable in
`damages, of whatever kind, as a result of the reliance on or use of the information
`contained herein.
`
`PRODUCT USAGE STATEMENT
`
`Read this entire manual and all other publications pertaining to the work to be
`performed before you install, operate, or maintain this equipment. Practice all plant
`and product safety instructions and precautions. Failure to follow instructions can
`cause personal injury and/or property damage. If the equipment is used in a manner
`not specified by the manufacturer, the protection provided by the equipment may be
`impaired. All personnel who work with or who are exposed to this equipment must
`take precautions to protect themselves against serious or possibly fatal bodily injury.
`
`Advanced Energy Industries, Inc., (AE) provides information on its products and
`associated hazards, but it assumes no responsibility for the after-sale operation of
`the equipment or the safety practices of the owner or user. This equipment produces
`or uses potentially lethal high-voltage, high-current, radio frequency (RF) energy.
`NEVER DEFEAT INTERLOCKS OR GROUNDS.
`
`TRADEMARKS
`
`® is a registered trademark of Advanced Energy Industries,
`Inc.
`
`Advanced Energy is a registered trademark of Advanced Energy Industries, Inc.
`AE is a registered trademark of Advanced Energy Industries, Inc.
`
`iv
`
`5702269-C
`
`Page 4 of 204
`
`
`
`Pinnacle™ Plus+ 10 kW
`
`Pinnacle is a trademark of Advanced Energy Industries, Inc.
`
`CUSTOMER FEEDBACK
`
`Advanced Energy’s technical writing staff has carefully developed this manual using
`research-based document design principles. However, improvement is ongoing, and
`the writing staff welcomes and appreciates customer feedback. Please send any
`comments on the content, organization, or format of this user manual to:
`
`(cid:127)
`
`tech.writing@aei.com
`
`To order a manual, please contact Technical Support:
`
`(cid:127)
`
`technical.support@aei.com
`
`5702269-C
`
`v
`
`Page 5 of 204
`
`
`
`Advanced Energy®
`
`vi
`
`5702269-C
`
`Page 6 of 204
`
`
`
`Pinnacle™ Plus+ 10 kW
`
`Table of Contents
`
`Chapter 1. Safety and Product Compliance Guidelines
`
`Important Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1
`Interpreting the Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1
`Type Conventions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1
`Danger, Warning, and Caution Boxes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2
`Safety Guidelines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2
`Rules for Safe Installation and Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2
`Interpreting Product Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3
`Product Compliance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-4
`Product Certification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-4
`Safety and Compliance Directives and Standards . . . . . . . . . . . . . . . . . . . . . 1-5
`Electromagnetic Compatibility (EMC) Directives and Standards . . . . . . . 1-5
`Safety Directives and standards . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-6
`Installation Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-6
`Conditions of Use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-6
`
`Chapter 2. Theory
`
`General Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1
`Output Impedance Range . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1
`Output Regulation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1
`Interfaces . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1
`Microprocessor Advantages . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2
`Displays . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2
`Arc-suppression Feature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2
`Theory of Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2
`Input . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3
`Housekeeping Supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3
`Inverter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3
`Output . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3
`Output Measurement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3
`DC Chopper Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3
`Logic Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3
`Remote Interfaces . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-4
`
`Chapter 3. Specifications
`
`Functional Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1
`Physical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3
`Electrical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-4
`
`5702269-C
`
`vii
`
`Page 7 of 204
`
`
`
`Advanced Energy®
`
`Maximum Allowable Reverse Time For a Given Frequency . . . . . . . . . . . . . . 3-6
`Reverse Time As A Function of Voltage Limit . . . . . . . . . . . . . . . . . . . . . . . 3-10
`Operating and Impedance Range Illustrations . . . . . . . . . . . . . . . . . . . . . . . 3-13
`Environmental Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-15
`Coolant Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-16
`
`Chapter 4. I/O Communication and Control
`
`User Port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1
`Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-2
`Signals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-2
`Pin-description Table . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-3
`DeviceNet™ Port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-5
`Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-5
`Pin Descriptions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-6
`Rotary Switches: Baud Rate and Addressing . . . . . . . . . . . . . . . . . . . . . 4-6
`Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-7
`Poll Command Message . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-7
`Response Message . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-9
`Explicit Messaging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-10
`Rear Panel LEDs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-10
`Module Status LED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-11
`Network Status LED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-12
`Passive Display Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-13
`Display . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-13
`LEDs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-14
`Active Front Panel/ Pinnacle Remote Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-15
`Connecting to the Remote Active Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-15
`Understanding the Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-16
`Control Key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-16
`Output Display Screen . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-16
`Soft Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-17
`Modify Knob . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-17
`Regulation Key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-17
`On/Off Buttons & LEDs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-17
`Arc LED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-17
`Control Panel Interface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-18
`Output Power Key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-18
`Control Key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-18
`Regulation Key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-19
`Two-Line Output Display Screen . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-19
`Setting the Reverse Time, Frequency, and Set point . . . . . . . . . . . . . . 4-21
`Soft Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-21
`Modify Knob . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-21
`Control Panel Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-21
`Understanding the Menu Options . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-22
`Using the Service Functions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-24
`
`viii
`
`5702269-C
`
`Page 8 of 204
`
`
`
`Pinnacle™ Plus+ 10 kW
`
`Checking Service-type Faults . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-25
`Checking Service-type Statistics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-25
`Checking the Total Energy Output . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-25
`Checking the Amount of Idle Time . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-25
`Checking the Number of Faults . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-25
`Checking the Number of Cycles . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-26
`Debugging Your Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-26
`Checking Your Master/Slave System Faults . . . . . . . . . . . . . . . . . . . . . 4-26
`Checking Your Hardware Configuration . . . . . . . . . . . . . . . . . . . . . . . . 4-27
`Checking Your Communications Card . . . . . . . . . . . . . . . . . . . . . . . . . . 4-27
`Checking Your Software Logic . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-27
`Checking Your ROM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-28
`Checking Your Software Versions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-28
`Using the Supply Functions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-29
`Setting the AE Bus Timeout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-29
`Setting the Supply Parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-29
`Setting Pulse Parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-29
`Enabling Pulsing at Current Threshold or Always . . . . . . . . . . . . . . . . . 4-30
`Setting Sync Pulse Hard Arc Detection Broadcast . . . . . . . . . . . . . . . . 4-30
`Setting The Unit as a Sync Pulse Transmitter or Receiver . . . . . . . . . . 4-31
`Selecting Constant Duty Cycle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-31
`Setting the Program Source . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-31
`Setting the Panel Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-32
`Selecting Remote or Local Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-32
`Selecting a Lock Code . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-32
`Selecting the Number of Clicks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-32
`Using Process Functions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-33
`Monitoring Your Process . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-33
`Viewing the Over-Voltage Density . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-33
`Resetting the over-Voltage Density . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-34
`Setting the Over-Voltage Timer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-34
`Viewing the Over-Current Density . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-34
`Resetting the Over-Current Density . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-35
`Setting the Over-Current Timer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-35
`Setting the Out-of-Set point Timer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-35
`Changing the Target Functions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-36
`Setting Process Limits . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-37
`Setting a Maximum Limit for Output Voltage . . . . . . . . . . . . . . . . . . . . . 4-37
`Setting the Maximum Limit for Output Current . . . . . . . . . . . . . . . . . . . . 4-38
`Setting the Maximum Limit for Output Power . . . . . . . . . . . . . . . . . . . . 4-38
`Setting Arc Handling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-38
`Setting the Voltage Arc Trip Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-38
`Setting the Arc Count Limit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-39
`Viewing the Arc Density . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-39
`Setting the Arc Shutdown Time . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-40
`Enabling Arc Handling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-40
`Setting Control Parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-40
`
`5702269-C
`
`ix
`
`Page 9 of 204
`
`
`
`Advanced Energy®
`
`Setting Recipes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-41
`Setting Joule Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-42
`Setting the Joule Set point . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-43
`Setting the Joule Threshold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-43
`Setting the Ramp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-44
`Standard Serial (Flash) Port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-45
`Standard Serial Port Description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-45
`Standard Serial Port Pin Descriptions . . . . . . . . . . . . . . . . . . . . . . . . . . 4-45
`Transmission Parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-46
`AE Bus (Host) Port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-47
`Pin Descriptions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-47
`Transmission Parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-48
`Switch Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-48
`Setting the Pinnacle Plus+ Unit’s AE BUS Address . . . . . . . . . . . . . . . 4-51
`Setting Baud Rates and Communication Mode . . . . . . . . . . . . . . . . . . . 4-53
`AE Bus Communications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-53
`AE Bus Protocol . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-54
`Header . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-54
`Command . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-55
`Optional Length Byte . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-55
`Data (Data Bytes) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-55
`Checksum . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-56
`Creating an Ideal AE Bus Communications Transaction . . . . . . . . . . . . . . . 4-56
`Understanding Command Status Response (CSR) Codes . . . . . . . . . . . . . 4-57
`AE Bus Commands . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-59
`Front Panel Illustrations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-98
`
`Chapter 5. Installation
`
`Unpacking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1
`Meeting Spacing Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1
`Cooling Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-3
`Cabinet Design . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-3
`Making Rear Panel Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-5
`Grounding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-5
`Connecting a Pinnacle Remote Active Panel . . . . . . . . . . . . . . . . . . . . . . . . . 5-5
`Connecting a Remote Passive Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-6
`Connection for User Port Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-6
`Connecting to the Standard Serial Port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-6
`Connection for Serial (Host) Port Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-6
`Contactor Interlock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-7
`Connecting Input Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-7
`Connecting Output Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-8
`Output Power Cable Recommendations . . . . . . . . . . . . . . . . . . . . . . . . . 5-9
`UHF Output Connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-10
`Military Spec Number . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-11
`UHF Connection without Interlock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-11
`
`x
`
`5702269-C
`
`Page 10 of 204
`
`
`
`Pinnacle™ Plus+ 10 kW
`
`UHF Connection with Interlock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-11
`Host Port Card (Master/Slave Operation) . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-12
`Master/Slave Pulse Port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-13
`Master/Slave Pulse Port Connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-13
`Master/Slave Pulse Port Pin Descriptions . . . . . . . . . . . . . . . . . . . . . . . 5-13
`Master/Slave Pulse Port cable . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-14
`Configuring Your Master Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-14
`Configuring Your Slave Units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-15
`Master/Slave Configuration Examples . . . . . . . . . . . . . . . . . . . . . . . . . . 5-16
`Monitoring Your Master/Slave System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-17
`Clearing Faults in a Master/Slave System . . . . . . . . . . . . . . . . . . . . . . . 5-17
`Master/Slave Input On/Off Combinations . . . . . . . . . . . . . . . . . . . . . . . 5-18
`Sync Pulse Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-18
`Sync Pulse Port Connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-19
`Sync Pulse Port Pin Descriptions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-19
`Sync Pulse Port Cable . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-20
`Configuring For Sync Pulse Transmit/Receive . . . . . . . . . . . . . . . . . . . . . . . . . . 5-20
`Sync Pulse Configuration Examples . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-20
`Simple Sync Pulse System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-20
`Sync Pulse Master/Slave System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-21
`Monitoring Your Sync Pulse System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-22
`Clearing Faults in a Sync Pulse System . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-23
`Rear Panel Illustration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-24
`
`Chapter 6. Operation
`
`Operating Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-1
`Understanding Pinnacle Plus+ Arc Handling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-2
`Voltage Arc Trip Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-2
`Frequency and Reverse Time Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-3
`Low Power Operation Versus High Power Operation . . . . . . . . . . . . . . . . . . . . . . 6-4
`Low Power Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-4
`High Power Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-5
`Cable Recommendations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-6
`
`Chapter 7. Troubleshooting and Global Customer
`Support
`
`Before Calling AE Global Customer Support . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-1
`First Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-1
`Checks with the Unit Powered Off . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-2
`Checks with the Unit Powered On . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-2
`Passive Front Panel Help Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-3
`Troubleshooting Table . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-4
`Checks if the Output Does Not Turn On . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-5
`Help Code Troubleshooting Table . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-6
`
`5702269-C
`
`xi
`
`Page 11 of 204
`
`
`
`Advanced Energy®
`
`Clearing the Error Code . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-12
`Error Code Troubleshooting Table . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-13
`AE Global Customer Support . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-19
`Returning Units for Repair . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-20
`Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-21
`Authorized Returns . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-21
`Warranty Statement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-22
`
`xii
`
`5702269-C
`
`Page 12 of 204
`
`
`
`Pinnacle™ Plus+ 10 kW
`
`List of Figures
`
`Figure 2-1. Pinnacle™ Plus+ functional block diagram. . . . . . . . . . . . . . . . . . . . . . . . . 2-2
`Figure 3-1. Pulse reversal times and self-run frequencies . . . . . . . . . . . . . . . . . . . . . . 3-7
`Figure 3-2. Pulse reversal time as a function of voltage limit (V-Limit) . . . . . . . . . . . . 3-11
`Figure 3-3. Operating range . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-14
`Figure 3-4. Impedance range . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-14
`Figure 4-1. 15-pin User port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1
`Figure 4-2. DeviceNet™ port with pin designations . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-5
`Figure 4-3. DeviceNet rotary switches and LEDs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-6
`Figure 4-4. Remote active panel connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-15
`Figure 4-5. Control panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-18
`Figure 4-6. Two-line output display screen . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-20
`Figure 4-7. Control panel main menu functions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-22
`Figure 4-8. Service menu map . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-23
`Figure 4-9. Supply menu map . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-23
`Figure 4-10. Process menu map . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-24
`Figure 4-11. Standard Serial port . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-45
`Figure 4-12. AE Bus port connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-47
`Figure 4-13. Rocker DIP switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-49
`Figure 4-14. Slide DIP switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-49
`Figure 4-15. Orientation of the AE Bus port and external DIP switch on the back panel 4-
`50
`Figure 4-16. Graphic representation of an AE Bus message packet . . . . . . . . . . . . . 4-54
`Figure 4-17. AE Bus communications transaction . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-56
`Figure 4-18. AE Bus communications transaction example . . . . . . . . . . . . . . . . . . . . 4-59
`Figure 4-19. Passive front panel (front view) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-99
`Figure 4-20. Active front panel (front view) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-99
`Figure 4-21. Remote panel (front view) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-100
`Figure 4-22. Remote panel (rear view) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-101
`Figure 4-23. Remote panel (dimensions) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-102
`Figure 5-1. Dimensional drawing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-2
`Figure 5-2. Clearances for Pinnacle™ Plus+ units stacked in a cabinet . . . . . . . . . . . 5-4
`Figure 5-3. Contactor interlock connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-7
`Figure 5-4. UHF connector and sleeve assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-10
`Figure 5-5. Rear view of UHF connector housing without interlock (back plate removed)
`5-11
`Figure 5-6. Rear view of UHF connector housing with interlock (back plate removed) . 5-
`11
`Figure 5-7. Pinnacle Plus+ master/slave interface Host card . . . . . . . . . . . . . . . . . . . 5-12
`Figure 5-8. Master/Slave Pulse port connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-13
`Figure 5-9. Master/Slave Pulse port cable . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-14
`Figure 5-10. Master/Slave Pulse system diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-16
`Figure 5-11. Sync Pulse connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-19
`
`5702269-C
`
`xiii
`
`Page 13 of 204
`
`
`
`Advanced Energy®
`
`Figure 5-12. Sync Pulse cable . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-20
`Figure 5-13. Simple Sync Pulse system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-21
`Figure 5-14. Sync Pulse master/slave configuration . . . . . . . . . . . . . . . . . . . . . . . . . . 5-22
`Figure 5-15. Rear view illustration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-24
`
`xiv
`
`5702269-C
`
`Page 14 of 204
`
`
`
`Pinnacle™ Plus+ 10 kW
`
`List of Tables
`
`Table 1-1. Electromagnetic Compatibility (EMC) Directives . . . . . . . . . . . . . . . . . . . . . 1-5
`Table 1-2. Electromagnetic Compatibility (EMC) Standards . . . . . . . . . . . . . . . . . . . . . 1-5
`Table 1-3. Safety Directives . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-6
`Table 1-4. Safety Standards . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-6
`Table 3-1. Functional Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1
`Table 3-2. Physical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3
`Table 3-3. Electrical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-4
`Table 3-4. Reverse Time Given a Self-Run Frequency . . . . . . . . . . . . . . . . . . . . . . . . 3-7
`Table 3-5. Reverse Time as a Function of Voltage Limit (V-Limit) . . . . . . . . . . . . . . . 3-11
`Table 3-6. Climatic Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-15
`Table 3-7. Coolant Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-16
`Table 4-1. User Port Pin Descriptions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .