`
`Exhibit 2029.001
`
`
`
`150 B. Wichterlov6 et al. / Catalysis Today 29 (1996) 149-153 zeolites was determined by chemical analysis after their dissolution. Cu t luminescence spectra of Cu2÷-zeolites reduced by hydrogen to Cu ÷-zeolites, in such a way that maximum intensity of Cu t was ob- tained, were recorded at a decay time of 5 /.ts, employing a kinetic spectrometer (Lambda Physik) equipped with an excimer laser (308 nm, 20 ns pulse). A detail procedure is given in Ref. [8]. IR spectra of NO adsorbed on Cu 2÷- zeolites were monitored at 298 or 150 K on transparent plates (about 10 mg/cm 2) using FT-IR Nicolet Magna-550 spectrometer. The catalytic data were obtained on a flow- through microreactor. NO decomposition (4000 ppm + He) was carried out in a total feed of 100 ml/min and catalyst weight equal to 3.5 mg of Cu. SCR of NO by propane was mea- sured with 1000 ppm of NO, 1000 ppm of propane, and 5.0 vol.-% of O 2 in He and cata- lyst weight equal to 3.5 mg of Cu. SCR of NO by ammonia (4000 ppm of NO, 4000 ppm of NH 3, 3.0 vol.-% of 0 2 in He) was performed at a total feed of 500 ml/min and catalyst weight of 4.1 mg of Cu. luminescence intensity 1,2- 0,6. 0,0 Cu-Z/a 0,8 .0,4 .0,0 1,6 0,8 0.4 O,C Cu-E 400 500 600 400 500 600 wavelength (nm) Fig. 1. Cu + luminescence spectra of Cu-ZSM-5 with Si/AI 14.1 and Cu/A1 0.20 (Cu-Z/a), Si/A! 22.6 and Cu/AI 0.26 (Cu-Z/b), Cu-mordenite with Si/AI 8.5 and Cu/A1 0.17 (Cu-M), and Cu-edonite with Si/AI 3.6 and Cu/AI 0.19 (Cu-E). emission band at 540 nm and IR of NO at 1896 cm-1 are indicated as shadow areas and corre- spond to the Cu-II site important for high silica zeolites and NO decomposition (see below). The Cu site of the type (I) (Table 1) with an IR band of Cu-NO at 1912 cm -I, Cu t emis- 3. Results and discussion Cu loaded zeolites of MFI, erionite and mor- denite structures with various Cu concentrations and Si/A1 ratios have been used to investigate the effect of different Cu co-ordinations on the activation of NO molecules and Cu-zeolite ac- tivity. Cu + luminescence, IR spectra of ad- sorbed NO on Cu E+ and Cu E+ ESR spectra have appeared to be highly sensitive to the co-ordination the Cu sites in the zeolite matri- ces. Figs. 1 and 2 illustrate the Cu + emission and CuE+-NO vibration bands in zeolites. The spectra indicate two main Cu co-ordina- tions in the MFI matrix, differing in population in dependence on the Cu concentration (Fig. 3) and content of aluminum in the framework (Si/Al) (cf. Ref. [8]). The deconvolution was made using Gaussian distribution. The Cu + absorbartce 0,6 0,4 0,2 0,0 Cu.7_Ja 1 1,2' 1,0 Cu-M 0,8 0,6/~ 0,4 0,2 O,C 1960 1920 1880 1960 1920 1880 .0,6 .0,4 0,2 0,0 1,0 0,8 0,6 0,4 Q2 0,0 wavenumbers (cm "1) Fig. 2. IR bands of nitrosyl species of NO adsorbed on Cu 2+ of Cu-ZSM-5 with Si/AI 14.1 and Cu/AI 0.20 (Cu-Z/a), Si/AI 22.5 and Cu/Al 0.26 (Cu-Z/b), Cu-mordenite with Si/Al 8.5 and Cu/AI 0.17 (Cu-M), and Cu-erionite with Si/A1 3.6 and Cu/AI 0.19 (Cu-E).
`
`Exhibit 2029.002
`
`
`
`B. Wichterlov6 et al. / Catalysis Today 29 (1996) 149-153 151 0,4- -~'c ~ 0,3- 0,2- "-=t,°o / 480 nm 0,1. o ._ E _~ o,o 0;0 0:2 0:4 0;6 Cu/AI Fig. 3. Dependence of the Cu + luminescence intensity of individ- ual bands on the Cu loading of ZSM-5. sion at 480 nm and ESR of Cu 2+ with the parallel component gll = 2.32 and All = 150 G, with pyramidal ligand field symmetry, was as- cribed to the single Cu 2÷ ion in the vicinity of two framework AI atoms, balancing Cu divalent charge [10]. This site is preferably occupied (Fig. 3). The Cu site of type (II) exhibiting IR band of Cu2+-NO at 1896 cm-1, Cu + emission at 540 nm and ESR signal with the parallel component gll = 2.27, Atl = 170 G was ascribed to the pla- nar Cu ion co-ordination in vicinity of one framework AI atom. These Cu 2÷ species should contain an extra framework oxygen ligand and prevail at high Cu loading and in zeolites of high Si/A1 (see Table 1). It is assumed that the Cu ions preserve their bonding adjacent to two or one framework A1 atom regardless of their divalent or monovalent state. The Cu ions in erionite are nearly exclusively Cu sites of (I) type, while those in mordenite matrix contain besides the Cu-I sites, some lower proportion of the sites (II) and in addition the sites with the luminescence at 450 and 510 nm, denoted as Cu-III and Cu-IV; for detail discussion of their co-ordination and redox properties see Ref. [9] and [ 10]. 3.1. Cu ion siting and redox properties The most populated sites in ZSM-5 are Cu-I and Cu-II sites, which differ dramatically in redox behavior. Fig. 4 illustrates differences in behavior of Cu in erionite, where the Cu-I sites prevail and in ZSM-5, with a population of both Cu-I and Cu-II sites. Table 1 Characterisation of Cu-I and Cu-II sites at zeolites Cu site denoted Cu + emission (nm) IR Cu 2 +-NO ESR Al local Cu 2 + (cm- 1 ) arrangement co-ordination a gll All (G) Cu-I 480 1912 2.33 150-160 Al-pairs square pyramidal Cu-ll 540 1895 2.28 180 single A1 square planar a Attributed according to Ref. [11]. Table 2 Cu siting vs. activity for SCR of NO by propane on zeolites Zeolite Si/Al Cu/Al Cu-total Cu-ll NO conversion (wt.-%) (wt.-%) (%) Erionite 3.60 0.16 2.93 0.2 16 Mordenite 8.51 0.11 1.62 ~ 0.2 38 ZSM-5 22.6 0.51 2.00 1.70 73 ZSM-5 14.1 0.44 2.87 1.38 71
`
`Exhibit 2029.003
`
`
`
`152 B. Wichterlou6 et al. / Catalysis Today 29 (1996) 149-153 (9 0 ¢- .I1 0 Cu%(NO) n a Cu='-(,NO) A A Cu-erionite Cu*-(NO). b cuZ*4NO) ~ Cu-ZSM-5 Cu z÷ - (NO) C B-A • . . . . . . . . 1900 1800 1700 1600 . , . , . , . 2000 1900 1800 1700 1600 1900 1800 1700 1600 wavenumbers (cm") Fig. 4. (a),(b) IR bands of NO (42 Torr) adsorbed on Cu-erionite (Si/AI 3.6, Cu/AI 0.26 ) and Cu-ZSM-5 (Si/A] 22.6, Cu/AI 0.48) on samples reduced by CO (100 Tort, at 725 K for 2.5 h and evacuated at the same temperature for 3 h), measured at 150 K (A) and after a temperature increase to 280 K in NO atmosphere (B). (c) IR bands of NO (42 Tort) adsorbed on Cu-ZSM-5 oxidized in oxygen (42 Torr, 725 K for 3 h) (A) and after temperature increase to 550 K in NO (B) and their difference (B - A). Substantially higher stability of the Cu+-di - nitrosyl species on ZSM-5, when compared to erionite, was revealed by their basically differ- ent behavior during low temperature and ambi- ent temperature experiments (see Fig. 4a,b). As indicated on Fig. 4c, the prevailing role of the Cu-II site species at the stabilization of the Cu+-dinitrosyl species of Cu-ZSM-5 is obvi- ous. 14. 12 SilAI ~/O / 10 I.I. 8 °6 44 2- 0- 010 0,5 1;0 1;5 z;0 z,s Cu-II ,wt. % Fig. 5. The effect of concentration of Cu-ll site on TOF (mole- cule/Cu atoms s) for NO decomposition over Cu-ZSM-5. Thus, the redox properties of the Cu ions are controlled by the local framework Si-A1 se- quences, however an overall Si/AI ratio, yield- ing a total negative framework charge, affects additionally the reducibility of the individual Cu ion. It follows that the Cu ions (site II), bal- anced by the single framework A1 atom, are the most stable in monovalent state and interact strongly with NO with formation of dinitrosyl complexes. 100 8 440 480 520 560 temperature, K Fig. 6. NO conversion at SCR by ammonia on Cu-erionite with Si/AI 3.6, Cu/Ai 0.16 (E), Cu-mordenite with Si/AI 8.5, Cu/AI 0.38 (M) and Cu-ZSM-5 with Si/A! 22.6, Cu/A1 0.33 (a), Si/AI 17.3, Cu/Al 0.20 (b), and Si/Al 14.1, Cu/A1 0.56 (c).
`
`Exhibit 2029.004
`
`
`
`B. Wichterlov6 et al. / Catalysis Today 29 (1996) 149-153 153 3.2. Catalytic properties Fig. 5 depicts dependence of turn over fre- quency of NO molecule per Cu atom for Cu- ZSM-5 of various Cu/A1 and Si/A1 ratios on the concentration of the Cu-II sites, the Cu ions balanced by a single framework AI atom. A linear relationship clearly evidences that the active sites for NO decomposition are the Cu-II sites. A splitting of the dependence into two lines reflects the effect of the overall negative framework charge. The Cu-II sites in a zeolite of a lower negative charge (higher Si/AI) are more active as their tendency to the monovalent state is supported by a higher Si/AI ratio. The unique role of the Cu-II site found in NO decomposition was not equally manifested in the NO selective reduction by NH 3 or propane. With SCR of NO by ammonia (see Fig. 6) the Cu sites balanced by A1 pairs should also partic- ipate in the catalytic reaction to explain their high activity of Cu-erionite and Cu-mordenite containing low number of the Cu-II sites (cf. Table 2). As for the selective reduction of NO with propane, contribution of both the Cu cen- ters of types (I) and (II) should also be antici- pated, as follows from Table 2. 4. Conclusions Cu siting in high silica zeolites is controlled by the local Si-A1 sequences in the framework. The redox properties of the Cu ions depend on both the local Si-AI sequence and total frame- work charge. The Cu sites neighbouring one framework AI atom display unique tendency to monovalent state, which is higher in zeolites of low negative framework charge. The Cu sites balanced by a single framework A1 are the active sites for NO decomposition, while in selective catalytic reduction of NO with ammonia or propane the role of the other Cu sites, adjacent to AI framework pairs, should be anticipated. Acknowledgements The authors thanks Dr. J. D~de~ek for the Cu + emission spectra of Cu-zeolites taken from his PhD dissertation and Dr. M. Markvart for providing the activity data for NH 3 by SCR. A financial support of the Grant Agency of the Czech Republic (project no. 203/93/1130) and of the US-Czech Program for Science and Tech- nology (project no. 93050) is highly acknowl- edged. References [1] M. lwamoto, Stud. Surf. Sci. Catal., 84B (1994) 1395. [2] B. Wichtedov~, J. D~de~ek and A. Vondrov~, J. Phys. Chem., 99 (1995) 1065. [3] M. Iwamoto and Y. Yahiro, Catal. Today, 22 (1994) 5. [4] B. Wichtedov~, Z. Sobalik and M. Skok~nek, Appl. Catal. A: General, 103 (1993) 269. [5] W.K. Hall and J. Valyon, Catal. Lett., 15 (1992) 311. [6] J.O. Petunchi, G. Sill and W.K. Hall, Appl. Catal. B:Environ., 2 (1993) 303. [7] G. Spoto, A. Zecchina, S. Bordiga, G. Ricchiardi and G. Martra, Appl. Catal. B:Environ., 3 (1994) 151. [8] J. l~de~ek and B. Wichtedov~i, J. Phys. Chem., 98 (1994) 5721. [9] J. D~de~ek, Z. Soball'k, Z. Tvar~kov~ D. Kauck2~ and B. Wichtedov~i, J. Phys. Chem., 99 (1995) 1632. [10] B. Wichtedov~i, J. D&le~ek and Z. Sobal~, Stud. Surf. Sci. Catal., 94 (1995) 641. [1 i] A.V. Kucherov and A.A. Slinkin, Zeolites, 6 (1986) 175.
`
`Exhibit 2029.005