`
`Another plasflo heedllght motoreflon
`
`‘94—?
`
`x
`
`EEK
` OW
`pro
`
`Paaword
`UserNarre
`I—IhrrrlrrrhorM-I?
`.
`
`I‘Ilp m
`
`.
`
`.
`
`mml:|fl
`
`We
`
`Penn We W “AM“ We“ WI”? MTV
`
`Erma musmmnmncme madam; Anotherplaoficheadflshtreotonfion
`
`Rewtslto3of3
`
`Thread: Allow. pith: holdlght restoration
`
`Lthadt
`
`Tl'l'eadTools
`
`searchThrall
`
`RateTheThread
`
`Ilsflay
`
`fig
`
` ALL IN ONE
`
`CHANGER
`is harem! J
`
`EASYTOUSE
`
`the yellowlng on my beloved 1 plece heedllghts
`
`”0“” 5 W“
`
`05-2505, 03:01
`Anetta-r mu: hoodlum mm“
`
`fl
`
`took! 0
`
`“Emma
`
`oulopala
`
`Joh (Jute:
`Locatm:
`Posts:
`
`Sep 2003
`Amtrak
`25?
`
`Opening tenths:
`
`This pram“ can be “53d 0" Pl'fltv much any plastic surface. headlights,
`tallllghts..
`
`film: To rerrovethe clearcoat on the OEM plastlc headllghto andto narrow:
`
`Required:
`
`Before you start make sure you have:
`
`1. 10 nm soc ketu to remove head-llghts
`
`2. Vadous grades of wet and dry. from 400 grade to 2000. 2 sheets of each
`
`3. Sanding block
`
`4. anchor wlth water and a small armors: of quality car wash dlsolved In I:
`
`5. A swirl rerrmrlng car polish" Megualrs, Mothers, 3m etc.
`
`AMAZING
`Paint. Cut-motion
`51 Protection
`
`"\E:
`
`6. Phstir: polish
`
`7. Mothers rretal pollh [yes realm!)
`
`7b. Heguairs Plastx
`
`8. A power buffer (If you have one, save rrondo tin-e)
`
`9. Mlcroflbre cloths
`
`10. Very good llghtlng
`
`11. Patlence
`
`www.mrlopia.orgtfonrmfoon-detolllngr‘fifi'ralanoflwer—plaslio-headlight—restoralion.hlml
`001
`O O l
`
`LKQ CORPORATION 1007
`LKQ CORPORATION 1007 134
`
`
`
`THEN 2
`
`Another plastic headlight restoration
`
`12. I added a Corona with lJn'e here, choice Is yours.
`
`amazonmm
`
`0k, firstly remove your headlights, I won't go hto, because 1 have a custom
`front bar, so my lights have been rrndded slightly. But basically there is 3
`10rn'n bolts on top. and 2 10n'n1 behind burrper bar.
`
`itarrerrber to unplug headlights of course, and than rerrnya them.
`
`Once they are out. examine how bad they realy are. Mhe were all yellowed.
`
`I pieced my headlight In a bench vice, sin-ply to hold I, made life ouch easier
`to work on... OK. lets begin.
`
`alt your wet and dry into the canon sizes for your sanding block, once done,
`put them into the bucket of water and let sit for 20 his or so, this n'altes
`them less likely to scratch. Alter 20 wins, ren'oye your first piece of wet and
`dry the 400 grit.
`
`Use the 400 grit sandpaper and start sanding the surface of the lights
`hngthw'lse In only a side to side motion. DON'T til-“NEE DIRECTIONS
`(leuupidown or circles}. I sprayed the surface of the headlights water to lube
`them, and started to sand. you don't have to push hardl soon you will notice
`the clear coat starts to corre ofi'. You'll be abh to tel where it Is and Isn't
`curring off.
`
`Repeat above procedure with the 600 grit sandpaper after all of the ciearcoat
`15 mounted (use water).
`
`{Inspect to see. how the clear coat or yellows-lg Is coming off)
`
`Repeat using 1000 grit sandpaper With water.
`
`(inspect to see, how the clear coat or yellowi'ig is caring off)
`
`Repeat using 1500 grit sandpaper with water.
`
`(Inspect to see. how the clear coat or yelhwhg b con'lng off)
`
`Repeat using 2000 grit sandpaper with water.
`
`By now they should be srrnoth and flat, there wl be sorre rricro nemng, but
`this B where the polishes cone Into play to remove aI th‘s.
`
`Firstly, hold them up to the light to Inspect, you cannot do this too often to
`see where more sending or work Is needed to get them perfect.
`
`I first covered them In the Mother rretel polsh and buffed them from right to
`Ieit etc, to ran-eve n'ost marks, then wiped wih the nicrofibre cloth to remove
`the excess.
`
`Then, hit them with your favorite swiri ren'mring poBh, buff this until it hazes,
`and leave for 20 wins or so. (crack a beer at this pol1t ) Then corre back and
`
`wwwautopieorgfforundmr—detailingJEGTST-anofliar-plaafic-headlight—raetoraiion .htrnl
`002
`002
`
`Phll Collin!
`Hewflfl
`“$9.90
`
`Unwed
`mam sand
`mum
`ensue
`
`Ellis!
`JLflln Blabar
`""8335
`“$3.95
`
`Bllaillhb lilo. Shh
`
`TRAINI
`ACADE
`
`The "Elustry
`Leaders
`
`In Detail
`
`
`
`712m 2
`
`Another plasflo headlight restoration
`buff off all the polish. Once cleared, inspect again (give yourself a pat on the
`back, they will be looking awesorre at this point)
`
`
`
`But more pollsh Is Involved, to get them super shiny and add a protectlve layer,
`grab the Plastx and follow the dlrectlons and applled as Instructed.
`
`I used my trusted Random (3le Buffer for all the polishing steps, you can work
`by hands, Its just more effort and tlrne in
`
`Pi“:
`E“
`[9‘
`J
`
`
`
`
`1- M“:
`- Hello, thank you for visilil
`Can I answer anyear eel
`““93““ WP"?
`
`The Next Big
`Thing In
`Surface
`
`
`Contamination
`Removal
`
`
`I haven‘t reinstalled them yet, as I am
`
`but looking at the headlights now, my ni
`
`
`
`
`I thlnk that s about It, any questions??
`
`
`Type wurmflsm hm and Prue!
`
`Introductory Price
`
`G Uzi-m - O B 1‘
`
`Too Mamrads? Beoomlneamemberof-
`
`
`CmeEaIHeadlidltshhfimles "0'
`:.'
`'_. "'
`I'I»._,'I'|:: "I
`We
`AdChoiCESED
`
`mrm, JDM DA one piece headlights. I rerrerrber back In hlgh school they used
`to go for Ilke Wfllset
`
`#2
`
`Share
`
`*3
`
`Nice write up. Thanks for posting this.
`
`05-25-05ll 03:06
`
`bum-nan o
`Wraith!
`
`Jon Etta:
`Lomtlon:
`Bethune!
`Pools:
`
`Dd: 2003
`Elarrmd Bar 8i
`
`104
`
`1
`
`05-25-05, 03:32
`
`Sullybob o
`stemmed Usa'
`
`
`
`Joh Date:
`Locatbn:
`Posts:
`
`Apr 2001
`nun-u, rx
`792
`
`www.autopia.orgiforumloar-detaiIingr’s673T-anomer-plastio-headlight-reslaoralion.hlml
`003
`O O 3
`
`
`
`7126“ 2
`
`Another plasflc headllght restoratlon
`
`Insert may qulp here...
`Shawn
`
`Share
`
`Pei-“£536 W if. Quote
`
`%raflprl0tecc‘lafi E I
`’
`
`
`20% off Wm.
`
`.
`
`« Previous Thread | Next Thread >>
`
`Thread lnfonnatlon
`
`There are uurrenfly 1 users bmwsing 111- thread.
`
`
`Panel-lg Pam“
`Yaumaymtpostnewu'reads
`You maynotpostreplies
`You maymtpoetaflammeris
`Yuumaymtedityurpasts
`
`Q
`
`laudeIsOn
`mareOn
`[MendeisOn
`[MmdeisOn
`HTML code is GIT
`Wells are On
`
`Phgbaelu are On
`Mada are On
`
`filrum Rubs
`
`
`Altl'resare GMT-8.112“ ml! 01:26.
`
`Copyright ompifim
`
`mum), 1999-2010,AubuDh-Wfl-NIRU1ISRe5erved
`
`-Autopia-4_1
`
`l
`
`mu; mum- keln Tu
`
`
`
`Main Sections Forum Categories Store Categories
`
`
`
`
`
`
`
`
`
`
`
`Cnpngfi; 1829mm. N1 (“Iagw'fMWervasi
`
`i Prwucy 53-35117 g ”Fr-1m $129
`
`www.autopie.orgtfarun'llcar-deteiIingfs673T-anomer-plastieheadlight-resboralion.himl
`004
`O O 4
`
`4M
`
`